€0.00
Checkout
0AM, DSG 7 (DSG 7) or DQ200 are different names for the robotic transmission with two dry clutches installed in some cars of the Volkswagen group. Maintenance of DSG 7 is to replace the transmission oil in the amount of 1.7 liters. In this case there are no check plugs. Filling of oil in DSG 7 is carried out strictly dosed.
Problems 0AM are associated with two nodes. Clutch and mechatronic. When the dual clutch is significantly worn, the 0AM mechatronic pump runs non-stop to maximize the output of the DSG 7 (DSG 7) clutch release rod. This causes the mechatronic electronic unit to overheat and melt the insulation of the DQ200 pump contacts. When this happens, the oil pump motor stops and the car does not respond to the shift knob. The short circuit causes the 0AM pump circuit fuse to melt.
The solution to this problem is to replace the 0AM electronic board with subsequent programming. Specialists of the company Mactrans with the help of an interface can program (sew) into an empty electronic block software both on the machine and without it. It is very important to realize that a short circuit inside the electronic control unit (ebu) 0AM does not happen accidentally. There are reasons for this. The next cause after a worn clutch is a hydraulic leak inside the DSG 7 (DSG 7) mechatronic. Realization of the problem, and that you are a victim of German technical progress comes in the form of a flashing key on the dashboard, and perpetually wet breather mechatronic 0AM. The pump motor does not stop after the ignition is turned on, it buzzes constantly. If nothing is done, the car will soon stop. There is only one way out - replacement of mechatronic DSG 7 (DSG 7). And the worst thing that can be in motion is the failure of the pressure sensor. In this case, the pressure in the system grows until the hydraulic accumulator does not shoot forward. After that, the car stops waiting for a tow truck.
So, 4 repair options for 0AM, DSG 7 (DSG 7), DQ200:
1. Replacing a worn 0AM clutch
2. Replacement of mechatronic DQ200
3. Replacing the clutch and DSG 7 mechatronic at the same time
4. Replacement of electronic unit of mechatronic and clutch 0AM
BESTSELLER
Mechatronics end cap for transportation DQ200 0AM DSG 7spd 0AM325120A O-CAP-0AM-RED
Model:
0AM325120A
Poland Stock:
20
Slovakia Stock:
110
Ukraine Stock:
149
Sold:
1036
Ends soon
Oil pan rubber gasket DQ200 0AM 0AM325025 0AM325219C
Model:
217300-ACM
Poland Stock:
47
Slovakia Stock:
1499
Ukraine Stock:
5318
Sold:
1030
Rubber gasket electronic board mechatronics DQ200 0AM DSG 7 03-up 0AM927377
Model:
0AM927377
Poland Stock:
189
Slovakia Stock:
1723
Ukraine Stock:
3621
Sold:
904
Clutch fork pusher dust cover, sealing cuff and rubber ring kit DQ200 0AM DSG 7
Model:
A-SUK-0AM-CA
Poland Stock:
23
Slovakia Stock:
441
Ukraine Stock:
1548
Sold:
802
Clutch fork pusher plastic clip VAG DSG7 0AM DQ200
Model:
GH-DQ200-S
Poland Stock:
3
Slovakia Stock:
1304
Ukraine Stock:
821
Sold:
762
BESTSELLER
DQ200 0am Mechatronic Breather 010409841A
Model:
FNK010409843A
Poland Stock:
23
Slovakia Stock:
278
Ukraine Stock:
258
Sold:
676
Ends soon
Sealing kit for repair hydraulic unit 0am , dq200
Model:
A-SUK-0AM-MT
Poland Stock:
14
Slovakia Stock:
197
Ukraine Stock:
764
Sold:
616
A set of rubber and Teflon rings with a retaining ring for the hydraulic accumulator 0AM DQ200, 0DD DQ400 - original
Model:
0AM-ACCUM-GSKIT
Poland Stock:
17
Slovakia Stock:
611
Ukraine Stock:
426
Sold:
561
O-ring rubber for pressure accumulator 0am dq200
Model:
0AMACSEAL
Poland Stock:
150
Slovakia Stock:
1026
Ukraine Stock:
6730
Sold:
544
Valve body filter DQ200 0AM DSG7 0AM325433D
Model:
0AM325433D
Poland Stock:
41
Slovakia Stock:
240
Ukraine Stock:
1909
Sold:
534
BESTSELLER
Pressure regulator solenoid white connector 0AM DQ200 DSG 7 GEN2 (N436, N440) F01R00WA02
Model:
F01R00WA02
Poland Stock:
8
Slovakia Stock:
50
Ukraine Stock:
39
Sold:
489
Ends soon
Shift Fork Pusher Oil Seal DQ200 0AM DSG 7 0AM325413A (24.3mm*13.5mm*8.7mm)
Model:
0AM325413
Poland Stock:
22
Slovakia Stock:
112
Ukraine Stock:
5205
Sold:
468
BESTSELLER
Input shafts seal kit, output flange seals, cover seal DQ200 0AM 02J409189E 0AM301212A 02M301189L 0AM301189E 0AM301733L
Model:
0AM-SAL-KT
Poland Stock:
33
Slovakia Stock:
316
Ukraine Stock:
506
Sold:
459
BESTSELLER
![Pusher fork thrust ring VAG DSG7 DQ200 0AM / [outer Ø 23.95 mm, int. Ø 14 mm]](https://maktrans.net/image/cache/catalog/easyphoto/30956/opornoe-koltso-vilki-tolkatelya-vag-dsg7-dq200-0am-nar-23-95-mm-vn-14-mm-1-228x228.jpg "Pusher fork thrust ring VAG DSG7 DQ200 0AM / [outer Ø 23.95 mm, int. Ø 14 mm]")
Pusher fork thrust ring VAG DSG7 DQ200 0AM / [outer Ø 23.95 mm, int. Ø 14 mm]
Model:
PI-47-95
Slovakia Stock:
356
Ukraine Stock:
437
Sold:
456
BESTSELLER
Clutch cylinder DQ200 0AM DSG 7
Model:
0AM-CHNEW-CLB
Poland Stock:
90
Slovakia Stock:
122
Sold:
404
Ends soon
BESTSELLER
Mechatronics separator plate DQ200 0AM 0AM325467J.
Model:
0AMSPLATE
Poland Stock:
19
Slovakia Stock:
150
Ukraine Stock:
359
Sold:
383
BESTSELLER
![Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R](https://maktrans.net/image/cache/catalog/easyphoto/17307/korpus-akkumulyatora-gidrobloka-mehatronika-dq200-0am-dsg-7-usilennyy-korpus-tolshchina-3-25-mm-0am325066c-0am325066ac-0am325066aa-0am325066r-1-228x228.jpg "Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R")
![Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R](https://maktrans.net/image/cache/catalog/easyphoto/17307/korpus-akkumulyatora-gidrobloka-mehatronika-dq200-0am-dsg-7-usilennyy-korpus-tolshchina-3-25-mm-0am325066c-0am325066ac-0am325066aa-0am325066r-2-228x228.jpg "Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R")
Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R
Model:
0AMACCUPD
Poland Stock:
7
Slovakia Stock:
30
Ukraine Stock:
12
Sold:
320
Ends soon
BESTSELLER
![Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]](https://maktrans.net/image/cache/catalog/alex_2/3/SOLRING-DQ250_1-228x228.jpg "Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]")
![Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]](https://maktrans.net/image/cache/catalog/alex_2/3/SOLRING-DQ250_2-228x228.jpg "Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]")
Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]
Model:
SOLRING-DQ250
Poland Stock:
38
Slovakia Stock:
433
Ukraine Stock:
34
Sold:
298
BESTSELLER
Valve body pressure sensor seal 0AM (DQ200) A-ORG-106468
Model:
A-ORG-106468
Poland Stock:
50
Slovakia Stock:
207
Ukraine Stock:
571
Sold:
279
![Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]](https://maktrans.net/image/cache/catalog/easyphoto/29185/poddon-maslyanyy-kryshka-mehatronika-vag-dsg6-dq200-0am-0am325219c-novyy-11-228x228.jpg "Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]")
![Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]](https://maktrans.net/image/cache/catalog/easyphoto/29185/poddon-maslyanyy-kryshka-mehatronika-vag-dsg6-dq200-0am-0am325219c-novyy-10-228x228.jpg "Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]")
Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]
Model:
0AM325219-NEW
Poland Stock:
13
Slovakia Stock:
252
Ukraine Stock:
516
Sold:
217
BESTSELLER
Clutch fork pusher rod kit DQ200 0AM DSG 7
Model:
0AMFRKKIT
Poland Stock:
12
Slovakia Stock:
53
Ukraine Stock:
57
Sold:
214
Ends soon
BESTSELLER
Clutch fork actuator dust cover DQ200 0AM DSG 7spd
Model:
217492-S
Poland Stock:
1
Slovakia Stock:
144
Ukraine Stock:
147
Sold:
210
![Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]](https://maktrans.net/image/cache/catalog/easyphoto/30957/tolkatel-vilok-pereklyucheniya-peredach-vag-dsg7-dq200-0am-obshchaya-dlina-70-mm-2-228x228.jpg "Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]")
![Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]](https://maktrans.net/image/cache/catalog/easyphoto/30957/tolkatel-vilok-pereklyucheniya-peredach-vag-dsg7-dq200-0am-obshchaya-dlina-70-mm-1-228x228.jpg "Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]")
Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]
Model:
PI-47-96
Slovakia Stock:
17
Ukraine Stock:
294
Sold:
202
Reverse/6 shift fork bearing DQ200 0AM.Reverse / 6th Gear Selection Fault
Model:
0AMFORKB
Poland Stock:
34
Slovakia Stock:
52
Ukraine Stock:
73
Sold:
193
Ends soon
Mechatronics (valvebody) mounting bolt kit DQ200 0AM 0CW DSG 7
Model:
0AMVBSCREW
Poland Stock:
4
Slovakia Stock:
403
Ukraine Stock:
442
Sold:
185
BESTSELLER
![Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]](https://maktrans.net/image/cache/catalog/easyphoto/28960/klipsa-pylnika-tolkatelya-vilok-pereklyucheniya-peredach-vag-dsg6-0am-dq200-nar-28-20-mm-1-228x228.jpg "Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]")
![Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]](https://maktrans.net/image/cache/catalog/easyphoto/28960/klipsa-pylnika-tolkatelya-vilok-pereklyucheniya-peredach-vag-dsg6-0am-dq200-nar-28-20-mm-2-228x228.jpg "Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]")
Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]
Model:
PR-CVR-0AM
Poland Stock:
16
Slovakia Stock:
232
Ukraine Stock:
921
Sold:
174
![Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]](https://maktrans.net/image/cache/catalog/DD-785-228x228.jpg "Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]")
![Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]](https://maktrans.net/image/cache/catalog/DD-786-228x228.jpg "Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]")
Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]
Model:
PI-37-30
Poland Stock:
49
Slovakia Stock:
127
Ukraine Stock:
51
Sold:
171
BESTSELLER
Mechatronics repair kit VAG 0AM DSG DQ200 0AM325066
Model:
K303799A
Poland Stock:
14
Slovakia Stock:
131
Ukraine Stock:
100
Sold:
163
BESTSELLER
Clutch fork pusher piston VAG 0AM DQ200
Model:
PRST-DS-0AM
Poland Stock:
11
Slovakia Stock:
208
Ukraine Stock:
586
Sold:
154
BESTSELLER
Valve body pump seal (mechatronics) DQ200 0AM DSG 7
Model:
0AMPUMPSE
Poland Stock:
42
Slovakia Stock:
239
Ukraine Stock:
251
Sold:
149
BESTSELLER
Clutch fork pusher VAG DQ200 0AM - rod length 74.90 mm
Model:
0AM325091F
Poland Stock:
54
Slovakia Stock:
122
Ukraine Stock:
513
Sold:
134
BESTSELLER
Hydroaccumulator mechatronics VAG DSG7 0AM DQ200 0AM325587F - repaired
Model:
0AM325587G-RE
Poland Stock:
8
Slovakia Stock:
49
Ukraine Stock:
6
Sold:
133
Ends soon
BESTSELLER
VAG DQ200 0AM Clutch Fork Pusher — Rod Length 77 mm
Model:
0AM-PSHR-LONG
Poland Stock:
4
Slovakia Stock:
38
Ukraine Stock:
69
Sold:
121
Ends soon
BESTSELLER
Overhaul kit DQ200 0AM DSG 7
Model:
K217900A-DZ2
Poland Stock:
9
Slovakia Stock:
20
Ukraine Stock:
16
Sold:
106
Ends soon
Battery Repair Kit 0AM DQ200
Model:
0AM32506FF
Slovakia Stock:
8
Ukraine Stock:
2
Sold:
106
Ends soon
BESTSELLER
Clutch pusher oil seal K1 / K2 DQ200 0AM DSG 7
Model:
0AMK1K2SEAL
Poland Stock:
27
Slovakia Stock:
383
Ukraine Stock:
313
Sold:
101
Shift fork 6 and Reverse gear VAG DSG6 DQ200 0AM (GEN2), 0AM311562K — (IMPORTANT! Before installation, replace the magnets with new ones!)
Model:
0AM311562L
Poland Stock:
3
Slovakia Stock:
26
Ukraine Stock:
77
Sold:
95
Mechatronics solenoid block separator plate DQ200 0AM DSG 7 0AM325483G (2 pcs in kit)
Model:
0AMSOLSP
Slovakia Stock:
129
Ukraine Stock:
98
Sold:
85
VAG DQ200 0AM 0AM325579D Mechatronics Oil Pump — Fits Gen1 and Gen2
Model:
0AM325579D
Ukraine Stock:
3
Sold:
75
Ends soon
Oil pump VAG 0AM DQ200 (Gen2) — 0AM325577F
Model:
PI-57-110
Poland Stock:
10
Slovakia Stock:
174
Ukraine Stock:
247
Sold:
73
Clutch fork pusher (with adjustable length) DQ200 0AM
Model:
PI-47-94
Poland Stock:
20
Slovakia Stock:
40
Ukraine Stock:
380
Sold:
67
BESTSELLER
DQ200 0AM DSG 7spd Bearing Set - 0AM311941, 0AM3112358, 0AM091185, 0AM311220
Model:
0AM-BEARING-KIT
Poland Stock:
1
Slovakia Stock:
13
Ukraine Stock:
28
Sold:
59
Ends soon
BESTSELLER
Axle oil seal L=R DQ200 0AM DSG 7spd DQ250 02E DSG 6spd DQ200 0AM DSG 7spd 03-up 02M301189B, 60x74x8
Model:
40183
Poland Stock:
5
Slovakia Stock:
26
Ukraine Stock:
36
Sold:
53
Clutch solenoid (K1, K2) forks shift (1-3, 2-4, 5-7, 6-R) 0AM DQ200 DSG 7
Model:
ONOFFSOL0AM
Sold:
48
BESTSELLER
Gearbox Fork Selector Push Rod Seal DQ200 0AM DSG 7 (20.2mm*14.3mm)
Model:
0AMFORING
Ukraine Stock:
1
Sold:
46
Ends soon
BESTSELLER
Hydraulic control unit (mechatronics, without electronic unit), refurbished DQ200 0AM DSG 7 - bench-tested and tested on the car
Model:
0AMVBREF
Poland Stock:
2
Ukraine Stock:
5
Sold:
44
Ends soon
BESTSELLER
BESTSELLER
Tool for removing bearing races in the front housing VAG DSG7 0AM
Model:
0AM-EXT-BR
Slovakia Stock:
21
Ukraine Stock:
88
Sold:
31