€0.00
Checkout
0AM, DSG 7 (DSG 7) or DQ200 are different names for the robotic transmission with two dry clutches installed in some cars of the Volkswagen group. Maintenance of DSG 7 is to replace the transmission oil in the amount of 1.7 liters. In this case there are no check plugs. Filling of oil in DSG 7 is carried out strictly dosed.
Problems 0AM are associated with two nodes. Clutch and mechatronic. When the dual clutch is significantly worn, the 0AM mechatronic pump runs non-stop to maximize the output of the DSG 7 (DSG 7) clutch release rod. This causes the mechatronic electronic unit to overheat and melt the insulation of the DQ200 pump contacts. When this happens, the oil pump motor stops and the car does not respond to the shift knob. The short circuit causes the 0AM pump circuit fuse to melt.
The solution to this problem is to replace the 0AM electronic board with subsequent programming. Specialists of the company Mactrans with the help of an interface can program (sew) into an empty electronic block software both on the machine and without it. It is very important to realize that a short circuit inside the electronic control unit (ebu) 0AM does not happen accidentally. There are reasons for this. The next cause after a worn clutch is a hydraulic leak inside the DSG 7 (DSG 7) mechatronic. Realization of the problem, and that you are a victim of German technical progress comes in the form of a flashing key on the dashboard, and perpetually wet breather mechatronic 0AM. The pump motor does not stop after the ignition is turned on, it buzzes constantly. If nothing is done, the car will soon stop. There is only one way out - replacement of mechatronic DSG 7 (DSG 7). And the worst thing that can be in motion is the failure of the pressure sensor. In this case, the pressure in the system grows until the hydraulic accumulator does not shoot forward. After that, the car stops waiting for a tow truck.
So, 4 repair options for 0AM, DSG 7 (DSG 7), DQ200:
1. Replacing a worn 0AM clutch
2. Replacement of mechatronic DQ200
3. Replacing the clutch and DSG 7 mechatronic at the same time
4. Replacement of electronic unit of mechatronic and clutch 0AM
BESTSELLER
Mechatronics end cap for transportation DQ200 0AM DSG 7spd 0AM325120A O-CAP-0AM-RED
Model:
0AM325120A
Poland Stock:
41
Ukraine Stock:
249
Sold:
1045
Ends soon
Oil pan rubber gasket DQ200 0AM 0AM325025 0AM325219C
Model:
217300-ACM
Poland Stock:
59
Slovakia Stock:
1679
Ukraine Stock:
5389
Sold:
996
Rubber gasket electronic board mechatronics DQ200 0AM DSG 7 03-up 0AM927377
Model:
0AM927377
Poland Stock:
192
Slovakia Stock:
1765
Ukraine Stock:
3698
Sold:
995
Clutch fork pusher dust cover, sealing cuff and rubber ring kit DQ200 0AM DSG 7
Model:
A-SUK-0AM-CA
Poland Stock:
24
Slovakia Stock:
478
Ukraine Stock:
1627
Sold:
786
Clutch fork pusher plastic clip VAG DSG7 0AM DQ200
Model:
GH-DQ200-S
Poland Stock:
3
Slovakia Stock:
1348
Ukraine Stock:
918
Sold:
770
BESTSELLER
A set of rubber and Teflon rings with a retaining ring for the hydraulic accumulator 0AM DQ200, 0DD DQ400 - original
Model:
0AM-ACCUM-GSKIT
Poland Stock:
18
Slovakia Stock:
631
Ukraine Stock:
481
Sold:
758
Sealing kit for repair hydraulic unit 0am , dq200
Model:
A-SUK-0AM-MT
Poland Stock:
22
Slovakia Stock:
220
Ukraine Stock:
808
Sold:
618
O-ring rubber for pressure accumulator 0am dq200
Model:
0AMACSEAL
Poland Stock:
150
Slovakia Stock:
1066
Ukraine Stock:
6836
Sold:
558
Valve body filter DQ200 0AM DSG7 0AM325433D
Model:
0AM325433D
Poland Stock:
43
Slovakia Stock:
287
Ukraine Stock:
1959
Sold:
518
BESTSELLER
Shift Fork Pusher Oil Seal DQ200 0AM DSG 7 0AM325413A (24.3mm*13.5mm*8.7mm)
Model:
0AM325413
Poland Stock:
42
Slovakia Stock:
96
Ukraine Stock:
176
Sold:
496
Ends soon
BESTSELLER
Pressure regulator solenoid white connector 0AM DQ200 DSG 7 GEN2 (N436, N440) F01R00WA02
Model:
F01R00WA02
Poland Stock:
8
Slovakia Stock:
92
Ukraine Stock:
62
Sold:
486
Ends soon
BESTSELLER
![Pusher fork thrust ring VAG DSG7 DQ200 0AM / [outer Ø 23.95 mm, int. Ø 14 mm]](https://maktrans.net/image/cache/catalog/easyphoto/30956/opornoe-koltso-vilki-tolkatelya-vag-dsg7-dq200-0am-nar-23-95-mm-vn-14-mm-1-228x228.jpg "Pusher fork thrust ring VAG DSG7 DQ200 0AM / [outer Ø 23.95 mm, int. Ø 14 mm]")
Pusher fork thrust ring VAG DSG7 DQ200 0AM / [outer Ø 23.95 mm, int. Ø 14 mm]
Model:
PI-47-95
Slovakia Stock:
360
Ukraine Stock:
439
Sold:
469
BESTSELLER
Clutch cylinder DQ200 0AM DSG 7
Model:
0AM-CHNEW-CLB
Poland Stock:
90
Slovakia Stock:
127
Ukraine Stock:
26
Sold:
453
Ends soon
BESTSELLER
Mechatronics separator plate DQ200 0AM 0AM325467J.
Model:
0AMSPLATE
Poland Stock:
20
Slovakia Stock:
157
Ukraine Stock:
399
Sold:
398
Input shafts seal kit, output flange seals, cover seal DQ200 0AM 02J409189E 0AM301212A 02M301189L 0AM301189E 0AM301733L
Model:
0AM-SAL-KT
Poland Stock:
60
Slovakia Stock:
389
Ukraine Stock:
540
Sold:
380
BESTSELLER
DQ200 0am Mechatronic Breather 010409841A
Model:
FNK010409843A
Poland Stock:
28
Slovakia Stock:
348
Ukraine Stock:
574
Sold:
348
BESTSELLER
Valve body pressure sensor seal 0AM (DQ200) A-ORG-106468
Model:
A-ORG-106468
Poland Stock:
57
Slovakia Stock:
227
Ukraine Stock:
573
Sold:
328
![Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R](https://maktrans.net/image/cache/catalog/easyphoto/17307/korpus-akkumulyatora-gidrobloka-mehatronika-dq200-0am-dsg-7-usilennyy-korpus-tolshchina-3-25-mm-0am325066c-0am325066ac-0am325066aa-0am325066r-1-228x228.jpg "Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R")
![Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R](https://maktrans.net/image/cache/catalog/easyphoto/17307/korpus-akkumulyatora-gidrobloka-mehatronika-dq200-0am-dsg-7-usilennyy-korpus-tolshchina-3-25-mm-0am325066c-0am325066ac-0am325066aa-0am325066r-2-228x228.jpg "Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R")
Valve body accumulator housing [mechatronics] DQ200 0AM DSG 7 [reinforced body - thickness 3.25 mm] 0AM325066C 0AM325066AC 0AM325066AA 0AM325066R
Model:
0AMACCUPD
Poland Stock:
2
Slovakia Stock:
51
Ukraine Stock:
47
Sold:
305
Ends soon
BESTSELLER
![Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]](https://maktrans.net/image/cache/catalog/alex_2/3/SOLRING-DQ250_1-228x228.jpg "Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]")
![Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]](https://maktrans.net/image/cache/catalog/alex_2/3/SOLRING-DQ250_2-228x228.jpg "Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]")
Solenoid Rubber O-Ring Kit 0AM DQ250 DSG7 3 rings per set [OD 15 mm, OD 14 mm, OD 13 mm]
Model:
SOLRING-DQ250
Poland Stock:
38
Slovakia Stock:
433
Ukraine Stock:
34
Sold:
302
BESTSELLER
Mechatronic accumulator DQ200 0AM DSG 7 / DQ400 0DD
Model:
ACCUM0AMDQ200
Ukraine Stock:
1
Sold:
299
Ends soon
![Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]](https://maktrans.net/image/cache/catalog/easyphoto/30957/tolkatel-vilok-pereklyucheniya-peredach-vag-dsg7-dq200-0am-obshchaya-dlina-70-mm-2-228x228.jpg "Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]")
![Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]](https://maktrans.net/image/cache/catalog/easyphoto/30957/tolkatel-vilok-pereklyucheniya-peredach-vag-dsg7-dq200-0am-obshchaya-dlina-70-mm-1-228x228.jpg "Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]")
Gearshift fork pusher VAG DSG7 DQ200 0AM / [total length 70 mm]
Model:
PI-47-96
Poland Stock:
20
Slovakia Stock:
29
Ukraine Stock:
295
Sold:
241
![Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]](https://maktrans.net/image/cache/catalog/easyphoto/29185/poddon-maslyanyy-kryshka-mehatronika-vag-dsg6-dq200-0am-0am325219c-novyy-11-228x228.jpg "Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]")
![Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]](https://maktrans.net/image/cache/catalog/easyphoto/29185/poddon-maslyanyy-kryshka-mehatronika-vag-dsg6-dq200-0am-0am325219c-novyy-10-228x228.jpg "Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]")
Oil pan/mechatronics cover VAG DSG7 DQ200 0AM 0AM325219C - [new]
Model:
0AM325219-NEW
Poland Stock:
10
Slovakia Stock:
279
Ukraine Stock:
539
Sold:
213
BESTSELLER
Clutch fork pusher rod kit DQ200 0AM DSG 7
Model:
0AMFRKKIT
Poland Stock:
15
Slovakia Stock:
30
Ukraine Stock:
113
Sold:
198
Ends soon
Mechatronics (valvebody) mounting bolt kit DQ200 0AM 0CW DSG 7
Model:
0AMVBSCREW
Poland Stock:
5
Slovakia Stock:
416
Ukraine Stock:
456
Sold:
181
BESTSELLER
Mechatronics repair kit VAG 0AM DSG DQ200 0AM325066
Model:
K303799A
Poland Stock:
14
Slovakia Stock:
137
Ukraine Stock:
122
Sold:
149
Clutch fork pusher piston VAG 0AM DQ200
Model:
PRST-DS-0AM
Poland Stock:
11
Slovakia Stock:
214
Ukraine Stock:
594
Sold:
147
![Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]](https://maktrans.net/image/cache/catalog/easyphoto/28960/klipsa-pylnika-tolkatelya-vilok-pereklyucheniya-peredach-vag-dsg6-0am-dq200-nar-28-20-mm-1-228x228.jpg "Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]")
![Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]](https://maktrans.net/image/cache/catalog/easyphoto/28960/klipsa-pylnika-tolkatelya-vilok-pereklyucheniya-peredach-vag-dsg6-0am-dq200-nar-28-20-mm-2-228x228.jpg "Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]")
Gear shift fork pusher boot clip VAG DSG7 0AM DQ200 [outer Ø 28.20 mm]
Model:
PR-CVR-0AM
Poland Stock:
16
Slovakia Stock:
232
Ukraine Stock:
963
Sold:
146
Clutch fork actuator dust cover DQ200 0AM DSG 7spd
Model:
217492-S
Poland Stock:
1
Slovakia Stock:
164
Ukraine Stock:
195
Sold:
145
BESTSELLER
Clutch pusher oil seal K1 / K2 DQ200 0AM DSG 7
Model:
0AMK1K2SEAL
Poland Stock:
27
Slovakia Stock:
383
Ukraine Stock:
313
Sold:
141
BESTSELLER
Clutch fork pusher VAG DQ200 0AM - rod length 74.90 mm
Model:
0AM325091F
Poland Stock:
54
Slovakia Stock:
126
Ukraine Stock:
522
Sold:
134
Reverse/6 shift fork bearing DQ200 0AM.Reverse / 6th Gear Selection Fault
Model:
0AMFORKB
Poland Stock:
37
Slovakia Stock:
59
Ukraine Stock:
137
Sold:
130
BESTSELLER
Valve body pump seal (mechatronics) DQ200 0AM DSG 7
Model:
0AMPUMPSE
Poland Stock:
42
Slovakia Stock:
259
Ukraine Stock:
280
Sold:
126
![Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]](https://maktrans.net/image/cache/catalog/DD-785-228x228.jpg "Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]")
![Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]](https://maktrans.net/image/cache/catalog/DD-786-228x228.jpg "Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]")
Hydroaccumulator rubber and teflon ring kit 0AM DQ200 [HCT]
Model:
PI-37-30
Poland Stock:
49
Slovakia Stock:
127
Ukraine Stock:
101
Sold:
125
Battery Repair Kit 0AM DQ200
Model:
0AM32506FF
Slovakia Stock:
9
Ukraine Stock:
1
Sold:
120
Ends soon
BESTSELLER
VAG DQ200 0AM Clutch Fork Pusher — Rod Length 77 mm
Model:
0AM-PSHR-LONG
Poland Stock:
4
Slovakia Stock:
50
Ukraine Stock:
73
Sold:
118
Hydroaccumulator mechatronics VAG DSG7 0AM DQ200 0AM325587F - repaired
Model:
0AM325587G-RE
Poland Stock:
4
Slovakia Stock:
87
Ukraine Stock:
12
Sold:
112
Ends soon
VAG DQ200 0AM 0AM325579D Mechatronics Oil Pump — Fits Gen1 and Gen2
Model:
0AM325579D
Ukraine Stock:
3
Sold:
111
Ends soon
Overhaul kit DQ200 0AM DSG 7
Model:
K217900A-DZ2
Poland Stock:
11
Slovakia Stock:
21
Ukraine Stock:
19
Sold:
104
Ends soon
Shift fork 6 and Reverse gear VAG DSG6 DQ200 0AM (GEN2), 0AM311562K — (IMPORTANT! Before installation, replace the magnets with new ones!)
Model:
0AM311562L
Poland Stock:
3
Slovakia Stock:
29
Ukraine Stock:
83
Sold:
95
BESTSELLER
Clutch solenoid (K1, K2) forks shift (1-3, 2-4, 5-7, 6-R) 0AM DQ200 DSG 7
Model:
ONOFFSOL0AM
Sold:
89
Oil pump VAG 0AM DQ200 (Gen2) — 0AM325577F
Model:
PI-57-110
Poland Stock:
10
Slovakia Stock:
187
Ukraine Stock:
247
Sold:
60
Mechatronics solenoid block separator plate DQ200 0AM DSG 7 0AM325483G (2 pcs in kit)
Model:
0AMSOLSP
Slovakia Stock:
155
Ukraine Stock:
119
Sold:
56
Clutch fork pusher (with adjustable length) DQ200 0AM
Model:
PI-47-94
Slovakia Stock:
66
Ukraine Stock:
386
Sold:
55
BESTSELLER
Hydraulic control unit (mechatronics, without electronic unit), refurbished DQ200 0AM DSG 7 - bench-tested and tested on the car
Model:
0AMVBREF
Poland Stock:
2
Slovakia Stock:
6
Ukraine Stock:
5
Sold:
46
Ends soon
BESTSELLER
Gearbox Fork Selector Push Rod Seal DQ200 0AM DSG 7 (20.2mm*14.3mm)
Model:
0AMFORING
Ukraine Stock:
1
Sold:
46
Ends soon
BESTSELLER
DQ200 0AM DSG 7spd Bearing Set - 0AM311941, 0AM3112358, 0AM091185, 0AM311220
Model:
0AM-BEARING-KIT
Poland Stock:
3
Slovakia Stock:
20
Ukraine Stock:
32
Sold:
45
Primary shaft oil seal 0AM O-OSL-0AM-IS-OU 56*40*8
Model:
O-OSL-0AM-IS-OU
Poland Stock:
11
Slovakia Stock:
134
Ukraine Stock:
427
Sold:
39
BESTSELLER
Axle oil seal left DQ200 0AM DSG 7spd DQ250 02E DSG 6spd DQ200 0AM DSG 7spd 03-up 02M301189B, 60mm*74,3mm*8mm
Model:
40183
Poland Stock:
7
Slovakia Stock:
39
Ukraine Stock:
39
Sold:
35
